• Welcome to SVTPerformance!

Ethanol Myths and Facts

Discussion in 'The Distillery' started by 04sleeper, Dec 17, 2010.

Thread Status:
Not open for further replies.
  1. 04sleeper

    04sleeper Runs On "Liquid Gold" Staff Member Super Moderator

    Messages:
    12,337
    Joined:
    Sep 17, 2005
    Location:
    Dallas, TX
    As quoted from the US Department of Energy:


    Ethanol Myths and Facts

    The U.S. Department of Energy (DOE) is committed to advancing technological solutions to promote and increase the use of clean, abundant, affordable, and domestically- and sustainably-produced biofuels to diversify our nation's energy sources, reduce greenhouse gas emissions, and reduce our dependence on oil.

    U.S. energy consumption is expected to grow over 18 percent by 2030. Biofuels must continue to play a significant role as we work aggressively to diversify our nation's energy sources and provide a balanced portfolio of energy solutions to help meet our growing demand for energy.

    Since 2007, DOE has announced over $1 billion in multi-year biofuels research and development projects. Integral to this work is the ongoing examination of reducing greenhouse gases as well as land and water use.

    The U.S. Department of Energy is carrying out a comprehensive plan to increase energy efficiency as well as the use of renewable fuels in the transportation sector. This includes basic and applied research and development projects with a broad range of technology demonstrations to help rapidly bring online next-generation biofuels.




    [​IMG]
    Future biofuels will be made from a wide range of hardy and fast-growing plants, such as switchgrass--which is a perennial native to American prairies. Switchgrass requires about a quarter of the irrigation and fertilization of row crops.
    Ethanol is a clean, renewable fuel. It is helping to reduce our nation's dependence on oil and offers a variety of economic and environmental benefits. As we look to broaden our domestic energy resources, common misconceptions about ethanol production and use need to be cleared up. This page addresses some of the common myths about ethanol.


    MYTH: In terms of emissions, ethanol pollutes the same as gasoline or more.

    FACT: Ethanol results in fewer greenhouse gas (GHG) emissions than gasoline and is fully biodegradable, unlike some fuel additives.


    •Today, on a life cycle basis, ethanol produced from corn results in about a 20 percent reduction in GHG emissions relative to gasoline. With improved efficiency and use of renewable energy, this reduction could be as much as 52 percent.

    •In the future, ethanol produced from cellulose has the potential to cut life cycle GHG emissions by up to 86 percent relative to gasoline.

    •Ethanol blended fuels currently in the market – whether E10 or E85 – meet stringent tailpipe emission standards.

    •Ethanol readily biodegrades without harm to the environment, and is a safe, high-performance replacement for fuel additives such as MTBE.
    [​IMG]


    In comparison to gasoline, ethanol made from cellulose and produced with power generated from biomass byproducts can result in an 86 percent reduction in greenhouse gas emissions.




    MYTH: Ethanol cannot be produced from corn in large enough quantities to make a real difference without disrupting food and feed supplies.

    FACT: Corn is only one source of ethanol. As we develop new, cost-effective methods for producing biofuels, a significant amount of ethanol will be made from more abundant cellulosic biomass sources.


    •Future ethanol will be produced increasingly from cellulose found in crop residues (e.g., stalks, hulls), forestry residues (e.g., forest thinning, wood byproducts), energy crops (e.g., switchgrass, sorghum), and sorted municipal wastes. Some promising energy crops grow on marginal soils not suited for traditional agriculture.

    •A high-protein animal feed, known as Distiller's Dried Grains with Solubles (DDGS), is produced in the process of making ethanol from corn.

    •The Energy Independence and Security Act of 2007 (EISA) requires use of 36 billion gallons of renewable transportation fuels in the U.S. by 2022. Of that quantity, 16 billion gallons must be cellulosic biofuels. Ethanol from corn is capped at 15 billion gallons.

    •The U.S. Departments of Energy and Agriculture's Billion Ton Study (PDF 8.5 MB) Download Adobe Reader found that we can grow adequate biomass feedstocks to displace approximately 30 percent of current gasoline consumption by 2030 on a sustainable basis – with only modest changes in land use. It determined that 1.3 billion tons of U.S. biomass feedstock is potentially available for the production of biofuels – more than enough biomass to meet the new renewable fuel standard mandated by EISA.






    MYTH: More energy goes into producing ethanol than it delivers as a fuel.

    FACT: In terms of fossil energy, each gallon of ethanol produced from corn today delivers one third or more energy than is used to produce it.


    •Ethanol has a positive energy balance – that is, the energy content of ethanol is greater than the fossil energy used to produce it – and this balance is constantly improving with new technologies.

    •Over the last 20 years, the amount of energy needed to produce ethanol from corn has significantly decreased because of improved farming techniques, more efficient use of fertilizers and pesticides, higher-yielding crops, and more energy-efficient conversion technology.

    •Most studies that claim a negative energy balance for ethanol fail to take into account the energy contained in the co-products.
    [​IMG]

    This graph shows how much fossil energy is required to provide 1 BTU of each fuel at the pump. The graph does not reflect energy derived from solar or other renewable sources used in the production of ethanol.






    MYTH: Ethanol-gasoline blends can lower fuel economy and may harm your engine.

    FACT: Ethanol blends in use today have little impact on fuel economy or vehicle performance.

    •While ethanol delivers less energy than gasoline on a gallon-for-gallon basis, today's vehicles are designed to run on gasoline blended with small amounts of ethanol (10 percent or less) with no perceptible effect on fuel economy.

    •Flex-fuel vehicles designed to run on higher ethanol blends (E85 or 85 percent ethanol) do experience reduced miles per gallon, but show a significant gain in horsepower.

    •As a high-octane fuel additive and substitute for MTBE, ethanol enhances engine performance and adds oxygen to meet requirements for reformulated gasoline.
    [​IMG]

    Race cars of the Indy Racing League benefit from the high performance characteristics of ethanol.





    MYTH: Rainforests will be destroyed to create the new croplands required to meet food, feed, and biofuels needs, thus accelerating climate change and destroying valuable ecosystems.

    FACT: Biofuels have the potential to significantly reduce global GHG emissions associated with transportation, but—as with all types of development—controls are needed to protect ecologically important lands.


    •In Brazil and elsewhere, laws have already slowed deforestation, and for the past decade China has converted marginal croplands to grassland and forests to control erosion.

    •Links between U.S. ethanol production and land use changes elsewhere are uncertain. We cannot simply assume that increases in U.S. ethanol production will lead to increased crop production abroad. Since 2002, during the greatest period of ethanol growth, U.S. corn exports increased by 60 percent and exports of Distiller's Dried Grains (DDGs) also increased steadily. In part, improvements in U.S. corn yield (about 1.6 percent annually since 1980) have enabled simultaneous growth in corn and ethanol production.

    •Greenhouse gas emissions will decrease dramatically as biofuels of the future are increasingly made from cellulosic feedstocks and as the associated farming, harvesting, transport, and production processes increasingly use clean, renewable energy sources.
     
  2. SID297

    SID297 OWNER/ADMIN Staff Member Administrator

    Messages:
    48,221
    Joined:
    Mar 27, 2003
    Location:
    Myrtle Beach, SC
    Good thread. I'm looking forward to more developments in cellulosic ethanol technology.
     
  3. stradt03

    stradt03 Active Member Established Member

    Messages:
    1,298
    Joined:
    Nov 13, 2000
    Location:
    North Carolina
    I'm working on a MAJOR project making biofuel from micro algae.
     
  4. 04sleeper

    04sleeper Runs On "Liquid Gold" Staff Member Super Moderator

    Messages:
    12,337
    Joined:
    Sep 17, 2005
    Location:
    Dallas, TX
    I'm sure this is the way we are headed in the future. Corn Ethanol will soon be a thing of the past.

    I have see this before. Great stuff! :rockon:
     
  5. mmustangsrus

    mmustangsrus boost makes daddy happy Established Member

    Messages:
    4,069
    Joined:
    Oct 10, 2005
    Location:
    NASHVILLE, TN
    another great thread from 04sleeper :rockon:
     
  6. oldmodman

    oldmodman Well-Known Member Established Member

    Messages:
    16,544
    Joined:
    Jun 27, 2003
    Location:
    West Los Angeles
    Now, if someone can just tell me why we don't have it here in greenie, stupid environmentalist California. The land of Priuses and tofu.
     
  7. dadro77

    dadro77 Deez nuts.... Established Member

    Messages:
    831
    Joined:
    Jul 16, 2006
    Location:
    south fla



    Ya, that is a shocker!!
     
Thread Status:
Not open for further replies.

Share This Page